Design and preparation of cut-off filter for observation scope

PANG Menglin; ZHOU Shun; GUO Feng; HANG Liangyi; XIAO Xiangguo

doi:10.5768/JAO202243.0201006

Journal of Applied Optics > 2022 > 43(2): 221-227. > DOI: 10.5768/JAO202243.0201006

PANG Menglin, ZHOU Shun, GUO Feng, HANG Liangyi, XIAO Xiangguo. Design and preparation of cut-off filter for observation scope[J]. Journal of Applied Optics, 2022, 43(2): 221-227. DOI: 10.5768/JAO202243.0201006

Citation:

PDF (1409 KB)

Design and preparation of cut-off filter for observation scope

1.
Xi'an Technological University, Shaanxi Province Key Laboratory of Thin Films Technology and Optical Test, Xi'an 710021, China
2.
Xi'an Institute of Applied Optics, Xi'an 710065, China

More Information

Received Date: October 09, 2021
Revised Date: November 11, 2021
Accepted Date: February 06, 2022
Available Online: February 15, 2022

Graphical Abstract

Abstract

Abstract

Based on the requirements of glued eyepiece for the optical filter in the observation scope system, a cut-off filter for the optical system of the scope was designed, which eliminated the half-wave hole of the filter and compressed the passband ripple. The optical filter was prepared by electron beam thermal evaporation technology and its transmittance was tested. The average transmittance in the range of 400 nm~630 nm is 95.76%, and the average transmittance in the range of 655 nm~800 nm is 0.06%. The sample passes the salt spray test and the mechanical firmness test, and the preparation results meet the design requirements.
- short-wave pass filter,
- thin film preparation,
- half-wave hole elimination,
- passband ripple compression

FullText(HTML)

References (26)

References

[1]	胡红伟, 李秀飞, 高龙岳, 等. 棱镜合束昼夜合一瞄准镜光学系统设计[J]. 光学与光电技术,2015(5):75-81. HU Hongwei, LI Xiufei, GAO Longyue, et al. Design of prism combined beam aiming optical system for day and night[J]. optics & optoelectronic technology,2015(5):75-81.
[2]	刘光灿, 白廷柱, 王毫球, 等. 轻武器新型瞄准镜研究[J]. 应用光学,2007,28(5):548-552. LIU Guangcan, BAI Tingzhu, WANG Haoqiu, et al. Research on a new type of sight for light weapons[J]. Journal of Applied Optics,2007,28(5):548-552.
[3]	刘康. 一种新颖实用的步枪瞄准镜[J]. 轻兵器,1997(2):13-17. LIU Kang. A novel and practical rifle sight[J]. Light Weapon,1997(2):13-17.
[4]	李玉瑶, 张婉怡. 长出瞳距军用瞄准镜目镜设计[J]. 光电工程,2015(10):33-36. LI Yuyao, ZHANG Wanyi. Eyepiece design of military sight with long pupil distance[J]. Opto-Electronic Engineering,2015(10):33-36.
[5]	牟鑫. 刑侦检测光学系统干涉滤光片的设计与制备[D]. 长春: 长春理工大学, 2011. MU Xin. Design and preparation of interference filter for criminal detection optical system [D]. Changchun: Changchun University of Science and Technology, 2011.
[6]	耿似玉. 用于紫外指纹仪的短波通滤光片的研制[D]. 长春: 长春理工大学, 2010. GENG Siyu. Development of short-wave pass filter for ultraviolet fingerprint scanner[D]. Changchun: Changchun University of Science and Technology, 2010.
[7]	关钧戈. 380 nm-570 nm短波通滤光片的设计与制备研究[D]. 长春: 长春理工大学, 2010. GUAN Junge. Design and preparation of 380 nm-570 nm short-pass filter[D]. Changchun: Changchun University of Science and Technology, 2010.
[8]	靳贵平, 庞其昌. 紫外指纹检测仪的研制[J]. 光学精密工程,2003,11(2):198-202. JIN Guiping, PANG Qichang. Development of ultraviolet fingerprint detector[J]. Optics and Precision Engineering,2003,11(2):198-202.
[9]	吴慧利. 深截止型日盲紫外干涉滤光片研究[D]. 北京: 北京理工大学, 2015. WU Huili. Research on deep cut-off solar-blind ultraviolet interference filter[D]. Beijing: Beijing Institute of Technology, 2015.
[10]	王庆. 短波通滤光片的研究[D]. 哈尔滨: 哈尔滨工程大学, 2006. WANG Qing. Research on short wave pass filter[D]. Harbin: Harbin Engineering University, 2006.
[11]	赵兴梅, 师建涛, 郭鸿香. 短波通滤光片膜系设计[J]. 应用光学,2006,27(5):415-418. ZHAO Xingmei, SHI Jiantao, GUO Hongxiang. Design of short-wave pass filter film system[J]. Journal of Applied Optics,2006,27(5):415-418.
[12]	吴博琦, 董连和, 孙艳军, 等. 光纤公共电视天线传输系统中短波通截止滤光片[J]. 中国激光, 2016, 43(2): 174-179. WU Boqi, DONG Lianhe, SUN Yanjun, et al. Shortwave pass cut filter in optical fiber public television antenna transmission system[J]. Chinese Laser, 2016, 43(2): 174-179.
[13]	唐晋发, 顾培夫, 刘旭, 等. 现代光学薄膜技术[M]. 浙江: 浙江大学出版社, 2006: 12-25. TANG Jinfa, GU Peifu, LIU Xu, et al. Modern optical thin film technology[M]. Zhejiang: Zhejiang University Press, 2006: 12-25.
[14]	卢进军, 刘卫国, 潘永强. 现代光学薄膜技术[M]. 2版. 北京: 电子工业出版社, 2011: 20-25. LU Jinjun, LIU Weiguo, PAN Yongqiang. Modern optical thin film technology[M]. 2nd ed. Beijing: Publishing House of Electronics Industry, 2011: 20-25.
[15]	GU Peifu , ZHENG ZhenRong, ZHAO YongJiang , et al. Study on the mechanism and measurement of stress of TiO₂ and SiO₂ thin-films[J]. Acta Physica Sinica, 2006, 55(12)6459-6463.
[16]	沈晓月. 近红外截止滤光片的研究与制备[D]. 长春: 长春理工大学, 2007. SHEN Xiaoyue. Research and preparation of near-infrared cut-off filter[D]. Changchun: Changchun University of Science and Technology, 2007.
[17]	马小凤, 余祥, 王英剑, 等. 倍频波长分离膜半波孔的消除[J]. 强激光与粒子束,2005,17(B04):155-158. MA Xiaofeng, YU Xiang, WANG Yingjian, et al. Elimination of half-wave holes in frequency-doubled wavelength separation membranes[J]. High Power Laser and Particle Beams,2005,17(B04):155-158.
[18]	黄伟, 张云洞. 消除短波通截止滤光片半波孔的方法[J]. 光学仪器,1999,21(4):145-148. HUANG Wei, ZHANG Yundong. The method of eliminating the half-wave hole of the short-wave pass cut-off filter[J]. Optical Instruments,1999,21(4):145-148.
[19]	薛建军, 朱建华, 蒋茂清, 等. 膜层渗透产生短波通截止滤光片半波孔现象的分析[J]. 光散射学报,2008(4):319-323. XUE Jianjun, ZHU Jianhua, JIANG Maoqing, et al. Analysis of the half-wave hole phenomenon of short-wave pass cut-off filter produced by membrane penetration[J]. Acta Light Scattering,2008(4):319-323.
[20]	刘卫国. 截止滤光片通带波纹的失调修正[J]. 西安工业学院学报,1995(1):41-44. LIU Weiguo. Misalignment correction of cut-off filter passband ripple[J]. Journal of Xi'an Institute of Technology,1995(1):41-44.
[21]	白胜元, 顾培夫, 刘旭, 等. 薄膜滤光片的光学稳定性研究[J]. 光子学报,2001,30(5):576-580. BAI Shengyuan, GU Peifu, LIU Xu, et al. Study on the optical stability of thin film filters[J]. Acta Photonica Sinica,2001,30(5):576-580.
[22]	潘永强, 白涛, 杭凌侠. 太阳模拟器AM0型滤光片及其稳定性研究[J]. 红外与激光工程,2013,42(5):1306-1310. PAN Yongqiang, BAI Tao, HANG Lingxia. Research on AM0 type filter of solar simulator and its stability[J]. Infrared and Laser Engineering,2013,42(5):1306-1310.
[23]	HANG Liangyi, LIU Weiguo, XU Junqi. Effects of various substrate materials on structural and optical properties of amorphous silicon nitride thin films deposited by plasma-enhanced chemical vapor deposition[J]. Chinese Optics Letters,2020,18(8):083101. doi: 10.3788/COL202018.083101
[24]	杭良毅, 徐均琪, 宋岩峰, 等. 多层介质滤光片的制备及激光损伤特性[J]. 西安工业大学学报,2016,36(12):947-953. HANG Liangyi, XU Junqi, SONG Yanfeng, et al. Preparation of multilayer dielectric filter and laser damage characteristics[J]. Journal of Xi'an Technological University,2016,36(12):947-953.
[25]	HANG Liangyi , LIU Weiguo , SONG Shigeng , et al. Simulation analysis and preparation of a high optical density laser protection filter[J]. Applied Optics, 59(11): 3315-3323.
[26]	张金豹, 史成浡, 耿浩. 多角度光谱测量法制备短波通滤光膜技术[J]. 光电技术应用,2020,171(2):73-76. ZHANG Jinbao, SHI Chengyun, GENG Hao. Preparation of short-wave pass filter film technology by multi-angle spectroscopy method[J]. Application of Optoelectronic Technology,2020,171(2):73-76.

[1]	ZHU Guangyi, JIN Shangzhong, WU Lei, ZHANG Guodong, MO Yunlong, YOU Yue, XUE Yuanyuan, ZHANG Yunlong, YU Bing, DONG Zaitian. Femtosecond pulse compression technology based on two-stage solid thin-film assemblies[J]. Journal of Applied Optics, 2025, 46(2): 427-434. DOI: 10.5768/JAO202546.0207003
[2]	ZHANG Jie, XUE Peng, ZHANG Rui, WU Qiannan. Snapshot spectral imaging technique based on field compression[J]. Journal of Applied Optics. DOI: 10.5768/JAO202546.0200000
[3]	FU Tai, CHEN Aishuai, HU Lei, GUI Jinbin, WU Jiaxue, WANG Xiaoshi, XU Luxin. Comparison of hologram compression coding based on wavelet transform[J]. Journal of Applied Optics, 2024, 45(1): 99-106. DOI: 10.5768/JAO202445.0102004
[4]	CUI Yumin, YIN Liju, SUI Liguo, ZHOU Hui, DENG Yulin. Compression and reconstruction of photon counting integral imaging[J]. Journal of Applied Optics, 2023, 44(2): 295-306. DOI: 10.5768/JAO202344.0202001
[5]	LIU Xiaomin, MA Zhibang, WANG Qiancheng, DU Mengzhu, ZHU Yunfei, MA Fengying, LIANG Erjun. Compression light field reconstruction and depth estimation[J]. Journal of Applied Optics, 2019, 40(2): 179-185. DOI: 10.5768/JAO201940.0201001
[6]	Cao Li, Zhong Shun-cong, Zhang Tao, Shen Yao-chun. Automatic single-point imaging system based on compressive sensing technique[J]. Journal of Applied Optics, 2016, 37(1): 29-38. DOI: 10.5768/JAO201637.0101006
[7]	CHEN Chao-ping, SHI Jian-tao, GUO Rui, BAI Bo, YANG Chong-min, GUO Hong-xiang. Design and preparation of mid-infrared bandpass filter[J]. Journal of Applied Optics, 2012, 33(3): 595-598.
[8]	XIAO Long-long, LIU Kun, HAN Da-peng, LIU Ji-ying. Application of compressed sensing in optical imaging[J]. Journal of Applied Optics, 2012, 33(1): 71-77.
[9]	MA Dong-mei, MA Cai-wen, BAI Yu-long. Modified listless 3DSPITH with ROI for hyperspectral image compression[J]. Journal of Applied Optics, 2011, 32(3): 446-451.
[10]	ZHAO Mi-yang, CHEN Wei-dong, LU Xiao-yan. Improvement of image compressing algorithm based on SPIHT[J]. Journal of Applied Optics, 2007, 28(4): 388-391.

Cited By

Cited by

Periodical cited type(6)

1.	陈祥雪，付子亲，王凤超，陈进，杨晶. 类H型结构的太赫兹带阻滤波器. 中国光学(中英文). 2024(04): 757-763 .
2.	薛钊，张海婷，杨茂生，宋效先，张晶晶，叶云霞，任云鹏，任旭东，姚建铨. 基于图形化石墨烯的可调谐宽光谱太赫兹吸收器的研究. 激光与光电子学进展. 2022(05): 12-18 .
3.	刘文，田晋平，杨荣草. 三层石墨烯组成的太赫兹可调宽频带超材料吸收器. 测试技术学报. 2022(05): 384-390 .
4.	高万，王建扬，吴倩楠. 基于双金属环的超材料太赫兹宽频带通滤波器的设计与研究. 激光与光电子学进展. 2021(05): 229-236 .
5.	初启航，杨茂生，陈俊，曾彬，张海婷，宋效先，叶云霞，任云鹏，张雅婷，姚建铨. 可调控的太赫兹多频带吸收器特性. 中国激光. 2019(12): 306-312 .
6.	米洋，吴倩楠，闫仕农. 多频带太赫兹滤波器的设计. 应用光学. 2016(05): 759-764 . 本站查看

Other cited types(1)

Get Citation

PDF

XML

Article views (395) PDF downloads (72) Cited by(7)

Turn off MathJax

Article Contents

Abstract

References

Design and preparation of cut-off filter for observation scope